642 016 03 30
Crankcase Vent Valve Heating Element 2004 & LATER
Located as part of the Oil Separator assembly - The red / orange grommet is furnished with the unit.
This is a small but, critical component, as it is important to not have the
crankcase vapors freeze (water vapor is present).
Oil and water
emulsification forms when vapors come in contact with cooler temperatures, freeze and i ce crystals can then easily erode the turbocharger intake blades. Sounds very strange but it is true.
000 090 36 01
Engine Air Filter Housing WITH ASSYST 2002-2003
Only for the early OM612 inline 5 cylinder engines.
000 094 93 08
Genuine Mercedes Air Intake Hose to Air Filter Housing 2002-2006
From air inlet to air filter housing .
This hose is made of plastic and not rubber.
000 090 62 01
Genuine Mercedes Engine Air Filter Housing WITH ASSYST 2004-2006
Only for the later inline 5 cylinder OM647 engines and only for models with ASSYST.
000 090 48 01
Genuine Mercedes Engine Air Filter Housing without ASSYST 2004-2006
Only for inline 5 cylinder engines. Only for standard models without ASSYST
(No maintenance sensor on air cleaner housing)
005 153 50 28
Intake Air Pressure Sensor All Diesel 2002 & LATER Located on the air filter housing/canister.
Used in all 5 Cylinder Diesels, 3.0L V6 Diesels and 2.1L 4 Cylinder Diesels.
651 153 00 28
Intake Air Temperature Sensor 2002 & LATER
T his is a relatively common failure item, which can cause the engine to go into limp mode.
This sensor is often oil soaked from vapors in the charged air stream. This is caused by oil leakage from the turbocharger shaft seals.
Carrying a spare sensor is suggested, as they are inexpensive and always seem to fail in the middle of nowhere.
010 153 72 28
MAP Sensor (Boost Pressure) 2.1L 2014-2016 Manifold Absolute Pressure (MAP) sensor - aka Boost Pressure Sensor
006 153 98 28
MAP Sensor (Boost Pressure) 2002-2003
Manifold Absolute Pressure Sensor
006 153 99 28
MAP Sensor (Boost Pressure) 2004 & LATER
2004-2018 2.7L I-5 and 3.0L V6 Diesel engine
Manifold Absolute Pressure (MAP) sensor
000 094 18 48
Mass Air Flow Sensor 2002-2003 Sprinter
Only for 2002-2003 OM612 Engine
Also know as: MAF sensor, Air Mass Sensor, Air Mass Meter, etc.
Installation is very simple and can be accomplished in just a few minutes.
000 094 32 48
Mass Air Flow Sensor 2004-2009
OM 647 2.7L 5 Cyl engine 2004-2006
OM 642 3.0L V6 engine 2007-2009
This part is also known as the MAF Sensor, Air Mass Sensor, Air Mass Meter, etc.
Not for 2010 and later BlueTec engines. The 2010 and later MAF sensor can be seen below.
611 230 02 65
Vacuum Pump 2002-2003
Mounts to front of OM612 engine
Pierburg is the OEM for this part.Both o-ring seals are included.
646 230 03 65
Vacuum Pump 2004-2006
For OM647 engine - Fits 2004-2006 models only.
Both o-ring seals are included.
646 230 03 65AFT
Vacuum Pump AFTERMARKET 2004-2006 For OM647 engineBoth o-ring seals are included.
611 997 07 45
Vacuum Pump O Ring-LARGE 2002-2006 Located at base of pump. This is the large diameter o-ring.
668 997 01 45
Vacuum Pump O Ring-SMALL 2002-2006 This is the smaller diameter o-ring on the back of the pump
Copyright © 1985-2024 Europarts. All Rights Reserved.
