Auxiliary Coolant Water Pump 2002-2006 Electric water pump in heater circuit
aka: Auxiliary Water Pump
Coolant Expansion Tank Cap 2002-2006 Expansion tank cap
aka radiator cap
Coolant Hose B 2002-2006 Attaches to electric coolant circulation pump.
Coolant Hose-A EGR Valve 2004-2006 Connects to side of EGR valve
Circulates engine coolant through the EGR valve.
Coolant Hose-C 2002-2006 C-shaped hose located right in the front of the engine, slightly below the turbo resonator on 2004-2006 models.
Coolant Level Sensor 2002-2006 Located in coolant reservoir on radiator
Coolant Temperature Sensor 2002-2019 Coolant t emperature sending unit.
Located on the thermostat housing and/or on the intake manifold.
90 degree electrical plug connection.
Held in place by metal clip, which is included along, with a new o-ring seal.
Coolant/Antifreeze-GENUINE MERCEDES-SPRINTER 2002-2019 1 gallon container to be mixed in equal parts with water
This is the newest formulation, MB part Q 1 03 0004 and is blue in color. It supersedes the previous coolants (Q 1 03 0002), which was yellow in color. The earlier fluid is not compatible with the blue fluid. A complete coolant flush and replacement is required, as the previous fluid has been discontinued. Do NOT mix the two different fluids together.
Flanged Coolant Pipe- At Water Pump 2004-2006 Attaches to flanged end of water pump on 2004-2006 I-5 diesel engines ONLY.
Not for 2002-2003 engines.
Hose-Intake Manifold to Aux. Coolant Pump 2002-2003 Small diameter hose from intake manifold to auxiliary coolant pump
Lower Radiator Hose 2002-2003 Sprinter Outlet or Lower hose
Lower Radiator Hose/Elbow 2004-2006 Outlet or lower hose elbow
Two way hose
Lower Radiator Rubber Mount 2002-2006
Radiator fits into one of these on each side.
Metal Coolant Pipe 2002-2006 Connects to coolant hoses at each end
Radiator Drain Plug 2002-2006 Small red plastic plug at bottom of radiator
Radiator Hose-Lower Extension Elbow 2002-2006 Outlet or Lower hose
Two way hose, much smaller diameter on one end, than on the opposite end
Attaches to end of coolant pipe on lower radiator hose.
See coolant pipe below....
Radiator Hose-Upper 2002-2006 Inlet or Upper hose
Radiator-Nissens 2002-2006 This radiator is manufactured by Nissens in Denmark. The quality is every bit as good as the OEM Behr radiator, and at a great savings, as well.
Thermostat w/Housing & Seal 2002-2006 OEM 87 degrees Celsius thermostat assembly, with seal and temperature gauge sensor
Thermostat is not removable from housing and must be purchased as a complete assembly.
Upper Radiator Mount-Rubber 2002-2006
Located under the clamp on each side of radiator
See clamp shown below
Upper Radiator Retainer Clamp 2002-2006
Covers upper rubber mount on each side of radiator
See rubber mounts shown below